-
摘要：以蛋白质含量高且价格相对较低的鸡骨架为原料，以水解度、蛋白质含量、粗脂肪含量和固形物含量、灰分、感光评定为指标，采用单因素试验研究了复合风蛋白酶对鸡骨架的酶解过程，比较各条件对鸡骨架的水解效果，得出了水解鸡骨架的最佳条件。再通过各种调料的复配从而得出最优的浓缩型鸡肉复合调料。24609
- 上一篇：啤酒酿造过程中酶制剂复配添加工艺优化
- 下一篇：全蛋粉海绵蛋糕的配方及工艺条件的设计
通过骨水比的单因素试验确定了1:1的骨水比最佳，测得的鸡肉蛋白质：30.35%；鸡骨蛋白质：26.13%；鸡汤蛋白质：2.71%；鸡汤灰分：0.17%；鸡肉脂肪：9.4%；鸡骨脂肪：8.91%；鸡汤可溶性固形物含量：3 Brix。蒸煮时间试验确定了90 min的蒸煮时间为最佳，测得的鸡肉蛋白质：26.32%；鸡骨蛋白质：24.13%；鸡汤蛋白质：5.78%；鸡汤灰分：0.29%；鸡肉脂肪：7.8%；鸡骨脂肪：7.83%；鸡汤可溶性固形物含量：4 Brix。
通过复合蛋白酶的添加量、水解时间、底物浓度的单因素试验测定鸡肉、鸡骨的最适酶解条件，其中鸡肉的最佳酶解条件为：酶解时间：3.5h;底物浓度：30%；酶的添加量：0.75%；其中鸡骨的最佳酶解条件：酶解时间：3.5h；底物浓度：25%；酶的添加量：1%.
上面三个实验条件条件优化完成后，通过调节添加剂的用量得到最佳的浓缩型鸡肉复合调料。本次试验通过单因素试验和正交试验确定复合调料的最佳配方为：鸡汤20 ml，鸡骨酶解液17 ml，鸡肉酶解液10 ml，鸡油3 ml。盐14%，糖1%，精3%，白芷粉0.1%，I+G 0.5%，单甘脂0.5%，野素0.5%，麦芽糊精35%、卡拉胶4.5%。
毕业论文关键词：浓缩型鸡肉复合调料；鸡肉；鸡骨；复合风蛋白酶
Study on the concentratedChicken tasteCompound condiment
Abstract:Chicken bones, which have a high content of protein but lower price, were used as the experimental materials. The degree of hydrolysis, protein content, crude fat content, solid content were the indicators. The single factor test was used to study the enzymatic process of chicken skeleton hydrolyzed byflavourzyme, and by comparing the effect of various conditions on the hydrolysis of chicken skeleton to get the optimum conditions of hydrolysis of chicken skeleton. Then through compounding various condiments intothe hydrolysate to get the best the concentrated chicken taste compound condiment.
The single factor experiment determined the optimal ratio of bone/water was 1:1, the chicken protein content: 30.35%; the protein content of chicken bone: 26.13%; proteincontent in chicken soup: 2.71%; chicken ash content 0.17%; chicken fat: 9.4%; fat in chicken bone: 8.91%; soluble solid content of chicken soup: 3 Brix.The optimal cooking time was 90min: chicken protein: 26.32%; the protein of chicken bone: 24.13%; protein inchicken soup: 5.78%; chicken soup ash: 0.29%; fat in chicken: 7.8%; fat in chicken bone: 7.83%;soluble solidcontent of chicken soup: 4 Brix..
The optimal enzymatic hydrolysis conditions was determined by the single factor experiment of enzyme concentration, hydrolysis time, the optimalenzyme solution conditions for chicken were: enzymatic time: 3.5h; substrate concentration: 30%; enzyme concentration: 0.75%; the optimal enzyme solution conditions of chicken bone were: enzymatic time: 3.5h; substrate concentration: 25%; enzyme concentration: 1%.
After the optimization of the above three experimental conditions , then the dosage of additives was adjusted to obtain the best concentrated chicken flavor compound condiment. By the single factor experiment and the orthogonal experiment, the best formula of compound condiment was:chicken soup 20 ml;chicken bone hydrolysate17 ml;chicken hydrolysate10 ml;chicken oil3 ml;salt 14%; sugar 1%; monosodiumglutamate 3%;angelica powder 0.1%; I+G 0.5%; monostearin0.5%;wild principle 0.5%;maltodextrin 35%; carrageenan 4.5%.
Key Words:Concentrated chicken taste compound condiment；Chicken；Chicken bone；Flavourzyme